The Carrier/Bryant air handler for a heat pump has a plastic pan inside the unit to catch condensation. The plastic pan material is of poor quality for the environmental temperature swings that it should have been designed in which to operate. After only 2.5 years, the pan cracked in July, water soaked the air handler insulation, and caused the ductwork to drip condensation on to the attic insulation and ruin the ceiling below the unit. The secondary protection pan under the air handler caught the water that dripped from the air handler but there was no protection for the plenum and ductwork which was collecting a vast amount of moisture from the soaked air handler. This is where the ceiling damaged occurred. Florida summers are hot and humid so the unit will produce a lot of condensation and a broken pan causes a lot of damage and high repair cost.The unit was under warranty so the replacement pan is free but the labor takes 4 hours to remove the coils, replace the pan, and replace the internal insulation in the unit. The internal insulation is not covered by the warranty so that is an extra cost. So there is about $700 of labor and insulation cost to replace a pan under warranty. Plus I need to repair my ceiling where the leak occurred. I suggest that Carrier should recall these pans and replace them with pans made of higher quality material. Perhaps made with plastic that is thicker, more flexible, and can withstand extreme heat and cold temperature swings. The pan is located next to the coil so when the heat pump is operating, the pan gets hot and obviously brittle. Also units should be designed so that parts can be quickly replaced. That seems to be a lost art. I have done some research and found that Lennox has a thicker more flexible pan that doesnt crack under normal use of the A/C and heat pump operation.

Freeze notices sent in email - servicemens visit confirmed bad fluid plugging A-coil. This is the 2nd service call on company recall for this area. Failures occur after first winter. Parts and tools on order. Wait and see about costs verses warranty. 362 days after new install of furnace and air conditioner.

When the unit arrived from the factory, the plastic door latch was broken. The HVAC installer retained the broken door latch and indicated theyd try to get a replacement. That never happened. When I called Carrier for a replacement part, they indicated they do not ship parts under warranty and told me to go buy the replacement part locally. If they wont honor their warranty with a little plastic part that cost them fifty cents to make, I dont feel theyll be honoring it for large ticket items.

Horrible gas furnace! Bought brand new in 2011 and every winter we have had problems. Now it’s shot! Big regret! Financial wrecked! This furnace was suppose to be top of the line. The heating elements went out and the burners! They will not work with you or budge! Minnesota winter is brutal and for this to go out on us every winter is horrible

I purchased and had installed a complete Carrier Heat Pump and Air handler system. The air handler failed 3 years after installation. Carrier warrantied the part but it cost over a $1000 for installation and freon. I looked at the evaporator coil and it was total rusted through. How they can manufacturer a product that fails completely after 3 years is unthinkable. Carrier was not willing to help defray any of the installation and freon costs. I will NEVER buy a Carrier product again.

Purchased a Carrier Infinity furnace and heat pump on 6/21/13. The compressor went bad in 10 days on July 3, 2013. Carrier replaced the unit. Less than 3 weeks later, the unit shut down. There was a loose wire on the outside unit. Twice the techs have been out to try to fix the water in the garage during the summer. Wrapped the outtake lines and flushed the line. They say it is just condensation. A few days ago, I discovered I have a steady leak under my house. They will have to contact Carrier because they are not sure of what the problem is but they think it is a bad gasket. Does anyone know if there has been a recall on this system or is there a class action lawsuit? I seriously think I have a lemon. I have not contacted Carrier yet, but will this week if the leak is not fixed.

As a manager for a mechanical contractor it is very hard to look my customers in the face and tell them that the new heat pump we just installed doesnt work. This has happened 3 times in less than 90 days. One was short compressor mounting bolts from the factory and the refrigerant line broke during shipment. Carrier said it was a warranty issue. I say a factory defect! They wanted me to fix and not provide a replacement. Took a lot of my time 15 plus hours but they finally replaced. Today new unit had a bad transformer and would only heat. When switched to cool compressor would only run for 15 seconds and would shut off on high limit. Brand new unit needs a reversing valve.Again Carrier wants me to repair and not provide a replacement unit. Carrier corporate is useless in solving my issues as a contractor. I feel for the all the homeowners. Trane is 60 yards away from CARRIER GREAT LAKES, my local carrier distributor. I walked over to Trane and will be paying more for heat pumps and will have to pass on the cost to my customers, but at least they answer the phone without attitude and have handled all of our other problems with a smile. MAKE SURE TO GET YOUR COMPLAINT IN BEFORE THEY COMPLETE THEIR MOVE TO MEXICO.

11/3/10: Burgors Always Dependable, (Pul drain not while); customer said that unit will run then furnace will go off. But not go on. Cleaned fuse off. Cycle unit a few times. Drain cleaned too, unit is running fine, filter ok too. Paid $100.00.11/15/10: Burgors Always Dependable, was here 4-6 times in the last two weeks do to furnace; will run fine for about 8-10 hours then furnace will go off and customer will reset switch on furnace. Service man did check; sensor cleaned, burner box check, salt test check passes at this time. Replace start, drain box cleaned and check to ok replace switch at limit box burner and will check heat exchange too. (Cycle Ok too!) Crack in heat exchanger not safe to run unit replace limit in burner box. Service man not know about 3 times. Customer was resetting furnace switch. Paid $150.00.Somewhere in here, Burgors tried to get me to give him $800 for the new heat exchange, I found out it is under warranty from Carrier and didnt go through him b/c Mechanical Heating and Cooling said I wouldnt have to pay the 800 b/c carrier will reimburse them.11/18/10: Mechanical Heating & Cooling, no heat replaced heat exchanger, also bad igniter system tested and running fine at this time; heat exchange under warranty. Paid $319.00. This is the bill I dispute b/c they charged me $111 for a rush fee without any knowledge of it being a rush fee or option to have it on a rush bases.11/19/11: Mechanical Heating & Cooling, No heat; furnace running upon arrival, let complete cycle, checked past fault codes 12 blower on after power up ran through several cycles running OK at this time, also flushed trap. Check incoming power connections, all Ok. Paid (n/c considering they were just there the night before).11/26/11: Mechanical Heating & Cooling, found furnace tripped on high temp limit, reset checked coil very dirty customer cleaned checked capacitor ok ,temp rise ok 46; cut hole in return in basement, cycled unit running ok at this time. Paid $89.00.After all this, Mechanical Heating & Cooling are now telling me that the venting system must not be the right size; seems to me that if this were true then why did my system run for approximately 6 yrs with no problems. Problems just now occurring; I spoke to _______ from Carrier and he stated that this is not uncommon; Well then if that is true, then why was the Venting for the system not properly installed? Wouldnt it still be Carriers fault since they installed it?

I had a Carrier heat pump and air handler installed in 2017 (Comfort 25HCE418.1.5 ton... w/SEER 14.5; Carrier Performance fan coil w/variable speed DC blower). I had all the scheduled maintenance and now the evaporator coil leaked and I am being told it will cost $1425 to fix just for labor! What good is having a new system if it costs this much to fix? I was told by the tech that they had to replace these evaporator coils after one year! Even with the parts covered the labor is cost prohibitive. If these systems cannot be maintained even with regular maintenance, which was also expensive, then they must be defective! My heating and cooling bills were also huge and the thermostat had constant problems - going out, or not registering the correct temperature. You would think these companies would be concerned about their reputations. You would think that the certified dealers would also be concerned about the quality of these products. You would think there was some integrity in this business.

Brand new unit installed by Carrier Dealer. Installed new outside AC condenser and new inside Air Handling Unit with electric heat in 2nd floor wall pocket as a complete package. Within a month, the bracket assemblies holding the evaporator coil are rusting and there is excess water always in the drain pan. Installer blames it on the design and components of the System and why worry, parts have a 10-year warranty. When got Carrier Rep on phone he said same thing! By the way, factory doesnt cover rust and installers labor warranty only good for one year. I am stuck with subpar parts and poor installation. Shouldnt have paid in a timely manner.

Purchased a new Carrier HVAC for my home in 2007. It was properly installed by licensed technicians. Ive had 9 (nine) major service calls requiring replacement of major components in less than 7 years. Thankfully I was covered for many of the services by a Sears master service agreement. That said, Ive still had to come out of pocket for several service calls for things not covered by the plan (i.e. Puron refills... 11 lbs 2 days ago ($450)). Similar scenario last year... slightly less. Thats just the AC. However, the furnace has made up more than half of those 9 service calls during the period. Ive spoken to an attorney who has advised a class action lawsuit. I would certainly be interested in joining such a suit. I have all documented service records to prove the faulty lemon that they manufacture.

Our Infinity series 25 heat pump was installed in 2006 and we had a 10-year parts and labor warranty included at that time. We have the system checked twice each year and things have worked well until recently. On our last bi-annual service call (January 24 this year), the outdoor temperature sender unit was determined to be bad and was replaced at no charge. Then three days ago, we received a system malfunction notice on our indoor thermostat so I called our service company and they were slammed, so we set up an appointment for today. The tech came out, spent an hour checking the system and determined the compressor is failing causing the thermal lockout conditions which were recurring on a regular basis (it is a Bristol compressor). He called their carrier supplier while he was here, went through the problems and trouble codes with them on the phone and then received the okay to replace the unit. There will be no charge to us due to the 10-year service agreement. I told him that I had read about the problems with the Bristol compressors and he said he was aware of the problems as well. He said they had a great supplier to work with and had some problems initially but no longer have them with respect to getting warranty replacements when they properly document the issues involved and the warranty is in effect. Apollo is our contractor here in Kennewick, Washington and theyve done a good job and have the right relationships with the manufacturer and vendors to get things done.

I built a new house in NC in 2006. I had two Carrier units installed. Every year, there has been a problem with one or the other. Either circuit boards, leaking coils and now both units cut on and off in the heat mode every minute or so. Labor has not been covered on any issues. I will never buy another Carrier product and will warn every person I know that intends on purchasing a new HVAC system.

My home is a little over 5 years old and I have 2 Carrier split units. Low coolant and of course a leaking condenser. Carrier units are specific and do not use generic parts so a normal $300 condenser is $953. Carrier responded with, We are sorry. Your unit is out of warranty by 4 months. There is NOTHING we can do. No offer to get me a reduced price on a crappy piece of hardware they engineered and installed in their units. Had 3 HVAC specialists say the same thing... NEVER USE A CARRIER. They dont care crap about their customers and they ** you on the parts because you have NO CHOICE but to get it from them. Going to dump them ASAP.

We recently installed a Carrier split type inverter gold series air conditioner and we did not regret anything about it. Yes, it cost us more than buying a regular window type air conditioner but because this Carrier split type has the inverter technology, it is more energy efficient therefore lower electric bills for us. It also cools the room faster and it is very quiet. You dont even know its already on because it doesnt create one sound. It also comes with a remote control that is very easy to use. And true enough, weve noticed that our electric bills have become lower the past few months that weve started using this Carrier split type air conditioner.

I will just be vague at this point to say that this is the worst air conditioner I have owned. This unit has had issues every year since I bought it. I bought it in Aug of 2008. Last year the compressor went out. The fan to the air handler went out the first year. And many instances in between. I heard of something from a service tech saying there was some recourse. I want recourse. I could not rate this unit since there are no negative options.

Carrier refused to fix a defective evaporator coil since it was 2.5 months past the 5 year warranty. They wouldnt consider contributing the part or any cooperation. I tried to send a letter to the president since customer service was useless and the customer rep wouldnt send it forward. They were also rude and refused to even consider the fact that an evap coil should not go out on an air conditioner that is only 5 years old. Id like to know if anyone has heard of any class action suits associated with defective coils. I cant believe all the comments about defective coils in this website.

Purchased a new home June 2010, with an 4 ton Carrier Air Conditions. I was informed that the unit came with a 10 year warranty. In 2013 the condenser went out and 2 years later the compressor has gone out. Carrier warranty department is stating the warranty was only for 5 year. This was not the information given at the time of purchase. Now Im left with buying a new system. What a ripoff.

Wow, horrible company. Bought a unit with a 10-year compressor warranty. Compressor developed a leak. They did nothing to repair/replace unit. Swore I would never buy another carrier. Bought a new house. Builder uses carrier. Less than a year the unit is rusting and corroding on the condensing housing and aluminum coil. Guess what carrier said, we will do nothing. Need I say more?

I purchased Carrier 2 ton and 3.5 ton Heat pump/AC units in Feb 2018. The 3.5 ton unit failed and had to be replaced in July 2019 (15 months). As of Oct. 4, 2019 this unit now needs additional new parts. The 2 ton unit also failed in Sept. 2019 and needs major parts replaced. My HVAC contractor is working with me and told me to contact Carrier customer service. Carrier customer service has informed me that their only responsibility is the warranty for parts. The $1000`s spent for labor is my problem. Bottom line is Carrier feels that if their unit lasts 1 year they have met their obligation. I know that everyone buys heating and AC units with the expectation that it will last more than 1 year. Carrier does NOT have that same expectation -- they hope it lasts a least a year so they are off the hook. Do Not buy Carrier products - unless you want to replace them quickly.

Bought our Carrier Infinity unit and had it installed in 2009. We were told it was the Cadillac of HVAC systems. Last year one of our thermostats failed which cost $500 to repair, just a few months outside of the warranty. Now, were in the middle of August in 100 degree heat and the entire unit failed completely. We need to replace a compressor, a relay, 2 capacitors and get refrigerant recovery. Total cost: $3,750. Meanwhile our house is sweltering. Despite my frustration, I politely called customer service for advice and the advanced service agent was rude. Theres nothing we can do, youre outside of warranty, sorry. Buyer beware. My advice - if youre buying an AC unit, look into warranty and try to get more than five years.

Module failed on model #FV4BNB006. I called an HVAC company. Carrier said the unit was warrantied for 5 years at the time this was purchased, although now the same exact unit is warrantied for 10 years. Sure enough, without knowing the exact date of install, Carrier claims the unit is out of warranty as of November of 2012. They dont care that the same unit now currently has a warranty of 10 years (new policy as of 2009); that the unit should not have failed 5 years prematurely; and that we, at the time we called, were only 3 months over the 5-year warranty. I spoke with a supervisor Jamie at customer relations. She was curt, only would repeat their policy and could care less about the situation of the same exact unit being warrantied for 10 years now. She didnt even know what the part was nor considered that it should not have failed at least 5 years premature! Oddly enough, there was another person listening into our conversation (another supervisor, Diane ID #**). She just came on the line without identifying herself and interrupted our conversation to say they would do absolutely nothing nor consider helping. Not only did I find this company absolutely uninterested in doing what is right, you could tell they were trained to do exactly the opposite. The way they operate, having big brother ready to chime in when they can to deny a claim, was downright creepy! Do yourself a favor. Look at all these miserable reviews of this awful company and steer clear of them. I have never written a review of a company before, but if theres one person I can help by reading this, its worth it. Carrier, you truly are an awful company and should be ashamed!

Like others, it seems that a few months right out of warranty something breaks. I installed a top of the line Infinity 96 5 years ago. Last week the furnace motor stops operating. My service company followed the repair instructions that suggests replacement of a main PC board and then a motor module. It turns out the main PC board did not need replacement and the motor module was defective - a couple of months outside warranty. Carrier wont accept the unused main PC board back once it was opened. At wholesale cost I was out $900 for the two parts. I would wish that Carrier would accept the PC board back for credit and replace the motor module under warranty. So far I have had no luck going up the chain at Carrier. Any suggestions would be welcome.

Bought new gas furnace and it doesnt work, keeps shutting off. Installer thinks its a bad heat exchanger. Have called Carrier 5 times and this has been 5 months and no heat. A waste of $2000. I have never been treated so bad in my life. My tenant below threatened to move out. I am ready to sue Carrier for their lack of care and not standing up to their word. I am going to have to contact the attorney general I guess. I dont recommend Carrier.

I paid $13,000 for an Infinity System in July 2007. On New Years Eve, the furnace failed and we sat for three days without heat until the blower motor could be replaced. This summer 2014 the heat pump failed and I had to pay $3500 for the bottom line Carrier heat pump to match the remaining system. $16,500 for a system with TWO major failures in seven years? I AM DONE WITH CARRIER.

I purchased my unit in 2007 and thru the company I bought it from, have a 15 yr parts and labor warranty. I have the Infinity thermostat and 3 ton unit heat pump and Infinity air handler. Ran okay for the first year or so but fast forward to today... Heres a rundown of the repairs on this unit. Ive had 7+ system malfunctions, many of them with multiple codes. The primary code is always 45. Ive had the air handler circuit board replaced 3 times - 3/2009 12/,2011, 9/2014 and a 4th one effective today due to the total shut down (8/2015) of entire system. Ive had the heat pump circuit board replaced also 9/2014, coils replaced 2/2014, and new wiring harness 10/2014. Ive been told that Carrier will eventually stop warranting the circuit boards.As everyone else, someone needs to be home when this service is done so taking time from work to be home for every repair can be very tough and expensive for someone whose company doesnt allow them or cant have them work from home. Im fortunate but in the long run Carrier should be doing something to recognize the problems their system has and make it right. My service company is great but eventually this will start to get very costly. Im done with Carrier and will be contacting the company I purchased it from regarding the lemon law. This just cant go on...

The heat pump function on our 1 and 1/2 year old Carrier unit is not functioning properly. What happens is that when a steady temperature of 68 degrees is set, the unit buzzes and then fails to come on. Then it buzzes again and fails to come on. Then buzzes again and fails to come on. (Repeated on purpose.) Had the installation company come out yesterday morning and they found nothing wrong. The board was not fried. They tested all terminals and said they were okay. Paid $80 for the visit that did nothing. Like to wake up every minute or so as your heat pump fails? Buy a Carrier unit!

Very dissatisfied with the quality of our Carrier 4 ton air conditioner (model 24ABB348A003). The compressor failed after only 3 years and it was not a blow out failure. The technician said it is internal failures most likely due to the quality of the compressor. The warranty of course only cover the park itself, not even the coolant they have to refill after reinstall the compressor. The diagnosis and the replace of the compressor cost about the 1/4 of the original cost and install of the air conditioner. It is ridiculous to have to spend so much on labor to fix a major component on an problem most likely due to the quality of their product.When speaking to a carrier representative, they do not stand by their product, only referring to the letter of the warranty agreement. Parts also does not include coolant cost. The excuse is that they do not know what exactly cause the compressor failure and they do not look at every compressor that failed, even those that failed in much less typical lifetime of the product. It is very good to know that Carrier does not take quality of their product seriously enough to diagnose major component that prematurely failed. Either that or they have so much failure on their compressor that they just dont care. Either conclusion does not speak well of Carrier as a company.

Have had system 17 yrs. The furnace would not run when installed, for first winter, many calls to installer. Charged us for all calls! This furnace has been totally undependable, with many repairs. Bishops in Muskegon MI sold and installed. Carrier should of known the problems with this new 2 stage! They never offered us anything. We must now replace this or continue throwing money at it. For the last 7 years we have to restart furnace at least daily, sand igniter monthly, etc. now the blower motor burnt out. We need dependable, and Carrier is not that. Do not recommend Carrier unless you want to keep replacing parts for overpriced prices.

Our 9-year-old Carrier furnace was blowing cold air. The repair guy for Carrier said we need a NEW FURNACE! If he only replaces the part, there is no guarantee it will work (up to $2,000 for repair). It s December (here in New York) and we have waited SEVEN DAYS and no part in sight! We will NEVER buy another Carrier!

I have issues with Carrier Canada warranty. I have carrier furnace. The heat exchanger is broken and the furnace still under warranty. I called carrier. They give me dealers phone numbers. I called and they told me they cant fix. I have to go for new furnace. That happened with 3 different carrier dealers. I called carrier customer service 3 times. They told me that they will forward my case to the management and the management will call me. Now its 2 week no call. Now I have to buy a new furnace which will cost me $ 4520.

The major manufacturers of HVAC equipment all buy the same parts. None is better quality than another. Carrier is ahead technologically, however.

This unit was purchased 2/10/2015, 5 years parts warranty, Model 48ES-A2406030TP. This unit was problem child soon after install, kicking into lockout mode, igniter failing to light, AC part did fine was furnace part constant trouble, numerous service calls, exhaust inducer fail, high temp sensor fails. I quit using installer because failed again in less than 10 minutes after driving out the driveway, got ahold of another service company, they found high temp sensor bad kicking off furnace before satisfying thermostat, got that repaired, next thing started periodic igniter fail or repeated attempt to light kick into lock out mode again. This would not fail when service man present, told me to wait till completely fail, find problem them, month later total fail.The service company owner came out this time, found no electricity, the junction block for wiring some screws loose likely from defective assembly, yup assembled in Mexico, Once that got locked down, ignited immediately, inducer motor quieter, blower quieter, was lacking enough electric all along. Runs like should. Point is I am out hundreds of dollars on a unit under warranty, I have contacted United Technology to see if they will reimburse for defective assembly, that is not excluded under their warranty. Submitted claim today, will see what they do about this, I will follow up with the outcome of this when I hear from them, I had previous Carrier lasted 20 plus years, cracked exchanger at 20 was still running, Why I bought another, this one with new controls been a nightmare, the faulty assembly my opinion caused all the trouble all along.

We purchased a large new home 5 years ago with 4 top of the line Carrier Infinity systems installed by a very large AC company with a very good reputation. We were never informed that you must register Carrier products within 90 days to receive the advertised 10 year warranty. I called about a year after install and thought it would be an easy adjustment for them to give us the full warranty but I was told by one agent and then her supervisor that they each always register their own personal products within the required time and I should learn to do the same. I wasnt amused by their advise. They then only were willing to give the minimum 5 year parts only warranty and replaced multiple air handler blower motors, control boards, temp sensors, controls, condenser unit fan motors and more parts without paying any labor. Fortunately due to having 4 units, when one downstairs unit goes out the cool air from upstairs keeps it very comfortable in our main area of the house, and if you didnt check the thermostat you would never know one was out. Our main area unit has been out for the last 6 months. On three separate service trips to repair the unit, it would go back out between a few hours to the next day. I was unsure when our 5 year warranty was over and as it turns out we had a tech back 4 days after the expiration, and on this trip another condenser fan motor was bad. Carrier Infinity units use a very high dollar motor, the book installed price without warranty is about $1400. I called Carrier and asked about a goodwill extension on that motor but was informed that as it may have been out while under warranty, it is now a few days past the expiration so it is not covered. These failures were not due to poor installation as there are 4 units all with different problems and were installed by a company that Carrier actually recommends as a top installer and they were as well as other companies were back to try to do many repairs. This seems to be a common Carrier experience. I read comments from Carrier dealers defending the product trying to deflect criticism on other installers but thats not realistic. I hope my experience helps others decide on a purchase and remember that even if they gave a 10 year warranty, you still pay for the labor to repair unreliable equipment.

I have a Carrier infinity 3-ton variable speed unit that is less than 2-year-old. The unit sweats when the air conditioner is running and is causing massive mildew/mold within the closet the downstairs unit is located. The Rep from New Orleans has been twice and said unit is working fine and closet needs insulated better. Had another HVAC come look and he said the unit should not sweat like this at all and the temp in closet was 73 degrees so no huge temp difference. I live in MS and temp and humidity are extremely high right now. Has anyone had these issues?

April 2008 installed high end Carrier dual (electrical/gas) system (furnace/heat pump/AC) system with Carrier Infinity Thermostat. The thermostat failed July 2013; replacement around $1100 (with maintenance plan discount). Gathered from technicians comments that problems with the Infinity device are not uncommon. For the cost of same, high quality should be expected. Perhaps unwise then for potentially purchasers to tie themselves into Carrier products that require such an expensive and fragile/poorly design controller.

Carrier heat pump problems cooling issues. Too mad to write about it. Unit less than 2 years old and broken down already. I want to join with Melanie from VA in a class action lawsuit.

Just installed a new 2 1/2 ton Carrier air conditioner. It emits 85 decibels of sound. It was advertised to be as low as 65 decibels. This is intolerable at night! Carrier could care less!!! NO recourse for me. Buying Carrier was a colossal blunder! I have no one to blame but myself. As it turns out American Standard was the best choice. Trane was second. That was based on exhaustive research, after the purchase. I found what seemed to be endless complaints against Carrier. How do you test drive an air conditioner? Caveat emptor!

I have 2 new Carrier system in a new built home and have had and continue to have several issues. I fully expected the builder and sub contractor to run for the hills but when I contacted Carrier, I did not expect them to just blow me off the way they did. I have been in the HVAC business for 30 years and never have had such poor customer support from a company. Carrier, unlike York and Trane, will apparently just sell their equipment to anyone. I thought Carrier to be one of the top 3 companies, but they sure changed that.

Just over ten years ago, we built a new home in Pennsylvania and decided on a Carrier heat pump because of anticipated quality and longevity. The outdoor unit is a 38YDB using a Bristol compressor. The compressor recently failed after 10 years and 6 months. Through our HVAC repair company, we knew that Carrier has had problems with the Bristol compressors (which are no longer used) and our repair company should know since they have been a dealer for almost 30 years.I contacted Carrier customer service and customer relations personnel by telephone and I made them aware (although they didnt acknowledge) of the companys compressor problems. I asked two questions : 1) would Carrier provide some satisfaction to our situation with regard to how close to the warranty the failure occurred? and 2) if we should choose to purchase a new Carrier unit, would the company provide any type of recompense toward the cost of the new unit? Carrier provided nothing in response to my inquiries. Essentially, No, were not going to provide any measure of customer relief or satisfaction and with the tone of, nor do we really care if you take your business elsewhere. This I will certainly do!

Six years ago purchased from Sears a new Carrier Infinity which cost $8,000.00. I thought that buying the supposed best system in the market & from a company like Sears I was making a wise decision. This was my first mistake. Yesterday March 15, just few month short on the six birthday of my very expensive Carrier & after expending the last 4 month $1,300 on repairs, I finally decided to end my nightmare & install a regular air conditioner, no frills just cool air.If you have a lot of money to throw away then buy a Carrier Infinity. If you want to be happy & save money on the long run please dont even think on buying a Carrier Infinity. The company who installed my new air, they told me that they see exactly what happened to me very very often. Look around & you will see Im not alone.

We have 2 Carrier AC units in our home. Installed brand new on new home in 2016 and there have been over $3,000 in labor and shipping costs to repair the units. They even charged us shipping for a replacement part that was dead on arrival and we had to pay shipping costs and labor costs again for the repairman to come out again with another part. That was a little over a month ago and now the same part needs replacing again!!! Never buy this brand ever again. They’re selling junk and then charge you shipping to replace parts under warranty but you’re stuck paying the labor. They must know they are selling defective parts and systems. Why would we have needed to replace the air handler parts 3 times in 3 years?

Since our Carrier air conditioner was installed in 2013 we have had to have the coolant replaced in it every year. We are told we most likely have a small leak but that these leaks are very difficult to find. Almost $300 again this year. If I want to pay to have them find the leak and then flush the system and replace the coolant the cost will be another $1000. Sorry to say we are very disappointed with this expensive purchase with which we have no recourse.

Payne is a division of Carrier Corp. I purchased a Payne central A/C unit in 2011 and have regretted it ever since. By 2014, the unit was not cooling my house. I contacted the installer who came to diagnose and repair. I was told there was a small Freon leak and my vent directions were set wrong and everything should be OK. 2016 - Again the A/C not cooling house. The original technician did not return my calls. I hired another company to diagnose/fix. They told me there was a Freon leak that caused damage to my unit and it needs to be replaced. I contacted Payne (a division of Carrier). Wow! A service tech responded with aggression/sarcasm. He kept saying Well why cant you tell me whats wrong the unit? I kept asking him to call the HVAC company to find out. He told me I had to hire yet another company at my cost and that Payne would not pay for this even though he had not talked to the first company. He agreed to talk to the first company. Days later, no response. The outside HVAC company told me they have tried to contact the agent several times. No response. I contacted customer relations at Payne. I was just informed my conversation is being recorded. This unit is still under warranty and now I have read reviews from this site, I am horrified! I have spent hours on the phone. It has been 90 degrees this week and I cant get anyone to help me.

I purchased a Carrier Infinity furnace in 2008 thinking that this furnace would last as long as my previous Lennox. My previous furnace lasted 18 years without any problems. Carrier instructed me that I had a 5 year parts warranty and does not include labor. I have just learned that Carrier offers a 10 year warranty on parts after 2008 and refuses to cover any cost of my repair. I have verbally stated that Carrier products are designed to fail just before 5 years are up and I seriously recommend that under any condition do not purchase any of their products ever. Their customer service is absolutely horrible and they like to hang up on many occasions. I wish I had never brought this piece of garbage.

Our heat pump compressor and related parts that were installed in our residence in 2011 required a replacement parts July 2016. We are very dissatisfied with the quality of our top of the line Carrier Heat Pump System. Parts are warranted for 10 years, but the issue remains, if the system is what Carrier boasts this system as their top of the line product, why do we need to have to pay for the compressor and related parts to be replaced.We are being charged a high rate of $167 per hour to replace these parts, along with $167 initial cost to diagnose the problems. It seems as though we are paying for the parts along with the repair, for a unit that should last 10 years. Sunset Air is the contractor replacing the parts and has estimated labor charges in excess of $1,300 just to replace the needed parts (8 hour job). Carrier has told us they are not responsible for labor charges, but the unit should hold up for the 10 years as boasted for their again top of the line unit.

I am an a/c contractor in Florida. I have installed a lot of carrier/Bryant systems and I have had no problems. I also installed Trane, Maytag, Gibson, Frigidaire, Westinghouse, Goodman, Amana, Nordine. I had so many problems with these units it almost ran me out of business. I am still doing warranty work on them and I stopped installing them two years ago. If you are having the types of problems Im reading about here with carrier you should change your contractor because I have no problems and have installed hundreds of these systems. If you are looking for a great system, buy carrier but make sure you also pay for a great contractor thats just as important.

Stay away from Carrier as they have really bad customer service. They dont keep replacement parts in stock locally and they are located in New York which is really far from Florida which is where I live. My unit needs a part replaced and they dont have it in stock either locally or in New York and they do not know when they will have it in stock. I live in Florida where you cannot be without air conditioner. Their 10 year warranty is non-existent as they will charge you for shipping the part and if you want to expedite it for next day they will charge you even more. Now how is it my fault that the part is not available locally. What kind of service are you giving your customers if you are selling a product that you do not have parts for.

Our unit is now 12 years old, the amount of repairs we have done to the unit, we could have replaced it with a quality Trane system three time over. A year into the system, our air handler developed a small leak losing Freon, under warranty, but labor with Custom Air of Florida cost over $700. Variable speed motor was replace three times costing us over $3000. Replaced capacitors every year at $200 a pop. Twice we had to have a leak fixed in the compressor coil, $1000 each time. Carrier is crap. Called them, told too bad in less words. We have a new Trane system going in this Tuesday with a heat pump, all labor and materials covered under warranty for 6K. Screw Carrier, go to Mexico, dont buy their junk.

Unfortunately, we were unaware of the horrible reviews and lack of customer service with Carrier. We have a brand new furnace, 6 months, and has been serviced 8 times in 6 months with 4 days without heat in the midwest. If this helps anyone else, do not buy a Carrier. POOR CUSTOMER SERVICE, DOES NOT BACK UP THEIR PRODUCT AND DOES NOT CARE ABOUT THE CONSUMER, ONLY JOB SECURITY FOR HEATING AND COOLING ON CARRIER FURNACES.

Purchased CARRIER ocean environment, 17.5 SEER Heat Pumps and air handlers for new home. During annual maintenance of my 4 systems, it was determined that one subject unit had leaked all refrigerant. Had to refill at a cost of $550. Maintenance company ordered a new coil under warranty. It took 5 weeks to deliver. Another $500 of refrigerant and $700 in labor was required to make the repair. CARRIER had a known problem with the coils. The lack of stock and the long fulfillment time are logically related. Several false ship promises further belie this contention. Carrier should have made me whole for all expenses. They did not exhibiting lack of concern for the customer and their brand.

5 compressors in five years - On June 29th, 2007, we installed a Carrier Infinity 3-ton 15.5 Seer heat pump model 25HNA636A003, the high efficiency unit, thinking that we would recoup our upgrade expenses in energy savings. Wrong! In 2009, the air compressor went out. We had installed under our five star warranty. Now, 7-30-12, we just had another compressor installed under the ten year warranty. The man who installed the latest compressor said this is a bad compressor by the name of Bristol. He wanted to sell me a new compressor for $2,500. Carrier knows this is a bad compressor and should replace it with one that wont keep burning out. I still have five years left on the five star warranty.

Had new Carrier air conditioner installed by Bloomington Heat and Air 7 years ago. Last year A/C failed and a hard start was added. A/C failed this week and I was informed compressor was bad. Good news, compressor covered by warranty... BAD news... labor and install is $1000. Nice. My old unit lasted 30 years. Nice progress.

My inducer has bad bearings, sounds like a 747 in my home when the furnace fires up. In addition, the evaporator is completely rusted. I have a seven year old system, and the builder did not register the system at install. I contacted Carrier and they basically told me to go fly a kite, even though they say they would have warranted their product had it been registered. The outside compressor is badly weathered, paint is peeling, rusted. The install guy said that although it has a Carrier brand on the outside, they took another system and merely added the Carrier logo to it. So after seven years Im looking at a replacement of the system. Guess what, it wont be a Carrier.

Purchased new Carrier Infinity series (Infinity Heat pump, Infinity air handler, Infinity Air purifier, Infinity control Thermostat, UV bulbs) through Sears in 2006. After the Carrier five year warranty expired: 1) Infinity Thermostat LCD failed $700; 2) Air purifier electrostatic element failed $800; 3) Circuit board on heat pump failed $700. Ok, the last one was due to a gecko crawling into the unit in cold weather and short circuiting the board. But then again, why did Carrier make such an open-to-the elements panel on the outside unit for sensitive electronics that would allow critters to crawl in? Dont forget the costs of the air purifier filter element - $100+ yearly (But you get a year’s service out of it still 8x more expensive than a regular Filtrete on sale at a big box store) and UV bulbs that Carrier says should be replaced yearly ($150 plus per bulb - 2 required).But the biggest shock: Last fall I wanted to clean the heat pump units outside coil and discovered that the aluminum fins on the Puron (Freon) coils have pretty much oxidized and are deteriorating (crumbling to dust) ON AN 8 YEAR OLD UNIT! Now I read that Carrier makes a Coastal heat pump that is more corrosion-resistant from salt air. Wonder why? I am ticked at having paid $10k new system + $2200 to-date in repair costs to Carrier to be an unpaid beta tester for their new technology. And the beta tester gift just keeps on taking. To Infinity and beyond are my estimated future repair costs on this system.

Our Carrier heat pump system was so quiet. The only way we knew it was on was the cool air filling the room. Although the Carrier system is more costly than other systems, it makes up the cost with efficiency. Our electric bill came down drastically after replacing our dinosaur.

I bought the 5 ton Carrier Infinity HNA26 indoor and outdoor unit heat pump system in 2007. My money was good; my purchase was not. Ducting was made to spec for the Carrier heat pump compressor in a new home heating some 3500 sq feet. 4 years later, 2011, the original compressor packed it in, a new compressor was installed costing me some $2000.00 more - labour and refrigerant. There were also numerous service calls prior, with among others the replacement of a honking reversing valve. Now in 2015 the 2011 replacement compressor has packed it in - another 4 years. Two (2) compressors shot! Junk! I phoned another heat pump outfit and they will install a comparable American Standard for some $12,500.00 here in British Columbia, Canada. That is a boat load of money to replace a Carrier unit that should have lasted some 15 or so more years. There should be a class action suit against Carrier for this!

Three top of the line Carrier units installed in the fall of 2006 has 100% rust and mold in all the copper evaporator coils inside the 3 air handlers. It has undergone consistent maintenance and service in the spring and fall every year. I contacted Carrier with the problem and they refused any assistance because the 5 year warranty has expired on the component, even though the local Carrier dealer who installed and serviced the units confirmed it is a manufacturing problem. The 3 unit models are: FV4BNF002, serial # 1606A82006; FV4BNF005, serial # 1106A87390; and FV4BNF005, serial # 4805A85599.If anyone reading this review is planning on installing a Carrier unit, please think twice and also read the 80+ other similar complaints. Also, please pass the word around so that others will not have to go through similar experience. The builder convinced us to install these Carrier units when we were considering another leading HVAC brand known for its excellent customer service and product reliability.

We built a new home with Schalmo Builders (Canal Fulton, OH) three years ago. We trusted their expertise in selecting a quality, reliable HVAC system for us. They chose a Carrier unit, and it’s been nothing but constant problems, breakdowns, costly service calls (with no resolution), run-around answers, fights & battles, hot summers with NO AIR, and winters with unbelievable heating bills due to our Carrier unit’s inability to properly switch from standard heat to very expensive “emergency heat.” Our condenser was replaced after less than one year. We’ve had more than a dozen service calls on the unit during the past three years.We are currently waiting for a replacement blower motor that has been on order for weeks now and is not due to arrive until mid October. We’ve been without air the entire summer (2019) due to our unit constantly blowing fuses. We’ve paid $600 in labor to replace all different kinds of Carrier parts that did not fix the issue. We have a parts warranty which is a joke because of expensive labor costs to fix a unit that is only three years old. Our builder will not admit that they gave us a terrible HVAC unit that we will most likely need to replace, saying their hands are tied. That’s reputable. BUYER BEWARE of complete junk Carrier units!

We installed a Carrier Infinity 4-ton heat pump model 25HNA648A30020 in a new custom built home in 2007, opting for the top of the line, high efficiency unit, thinking that we would recoup our upgrade expenses in energy savings. Wrong! So far, we have had to replace a compressor, a coil, and a circuit board. All these parts were covered under Carrier warranty, but not the labor. All told, we have spent $3887 in labor and Freon (R410). We would have been better off going with the builder grade unit. Our HVAC system undergoes routine maintenance twice a year, so this is not due to a lack of proper routine service. We have done everything the HVAC company and Carrier recommended. At one point last year, two Carrier field service reps came to my house to evaluate our duct system, at the request of the owner of our HVAC company. The Carrier field service reps agreed to the recommended duct redesign. I was willing to do anything to correct the problems and make the frequent equipment failures stop. I saved all service records and have over 30 pages of them now. The same unit went out 2 days ago for the second time in the middle summer in hot, humid South Carolina. HVAC company has not been able to run a diagnostic yet because the compressor was too hot. To add insult to injury, we were told the warranty on the Bristol compressor replaced in April of this year would not even last for the balance of warranty on the HVAC unit. That signaled to me that Carrier expects it will fail again within the balance of the heat pump warranty and they dont want to pay for it.Given numerous similar complaints and universal lack of responsiveness on the part of Carrier customer service, it would seem that a class action suit might be in order. Too bad, Carrier prefers to let it get to that stage rather than faithfully standing behind their products. Doing the right thing might be expensive, but not nearly as expensive as it will be when attorneys get involved.

RUN AWAY! I always trusted in the brand, however, when I needed help from Carrier, they dont want to deal with their certified providers. I purchased an Air Handler and a Condenser from two providers listed on the Carrier website to solving my cooling problem. The issue was not solved, and now they want to sell me another HVAC system more powerful. They will not give me any discount for the product that I just bought and have less than 2 months of usage. Honestly, it is a joke, they want to sell more and more equipment without caring about customer satisfaction. Very disappointed with Carrier.

I purchased a new home in Sept. 2007 with a Carrier HVAC system. I made several complaints to the installation company during the first year about quality of the installation. Three trips and the company assured me they had corrected all items. In just under three years, cooling coils on both units of the two-unit system failed and had to be replaced. Replacement coils were furnished under warranty but the bill was $1500. I hired another company to do an analysis of system. Based on this inspection, I filed a formal complaint with state licensing bureau. Finally, about $4,000 worth of corrective action was performed at no charge. Corrections included the installation of an additional return air ducting that was not installed but was on original design.Well, now 3 years and 5 months later, the cooling coil on one unit has again failed leaking out all Puron over a weekend. Carrier will not provide replacement coil under warranty. Work is being completed today and Id guess the bill will be around $1500. So HVAC repairs of $3000+ in 6 years on new home has to be considered unacceptable quality.

I bought a Carrier Mini Split Air Conditioner Model:40MHHC12 in 2018. After 1 season of use, it stopped producing cold air. A major component had failed (condenser coil)! The installer (ARS in Florida) refused to help, saying the unit must be maintenanced twice a year to stay under warranty for labor (brand new!). Carrier declined to comment about their unit failing after 1 year, or consider replacing the unit. The parts were under warranty, but the labor would cost almost $1000.00. Carrier said they would send a representative out to the installer company to review the issue, but after a month of me trying to find out the status of the issue, they finally just told me that there was nothing they would do. I would not recommend this company for air conditioners. High priced products with lousy quality.

Lake Lure NC. After two years turned on A/C for recently completed bonus room for future retirement house. Unit started short cycling. Two tech visits later condenser coil found to have two or more leaks. Contact with Carrier customer service and they admit product defect and hide behind one year labor warranty. They are sorry I am dissatisfied. I own four Toyotas because they stand behind their product. Last Carrier product I will own. I called by HVAC contractor in Fl and he is replacing my failing unit with Rheem. Sorry Carrier, customer service doesnt take an Einstein.

I am a Mechanical Contractor in Detroit area. I have installed many Infinity Systems (We stopped selling them in 2012 because of all of the problems!). My own house I built in 2009 has three systems, has had 5 compressors replaced, 4 contractors, 3 controls and one complete condensing unit in 2015 which now does not work and my house is 81 degrees! INFINITY means as long as you have it you will have aggravation. It is junk. I live right on Long Lake Rd in Bloomfield Hills and on June 26th I will remove all Infinity equipment and replace with Trane. I will put all three furnaces and condensing units on the main road with a 12 foot banner which reads, This is the kind of junk to expect of Infinity equipment. Come by and check it out ** just east of Telegraph!!!

I paid $6500 for a new furnace (59SC5A)/AC in July of 2016. Turned on my furnace on Friday 10/12/18 remotely via wifi thermostat and came home to NO heat. Called after hours service at $145 just to walk in and diagnose the problem. Bad gas valve that they do NOT carry and have to order and I have to PAY for the service call and the labor which is unacceptable. No heat for the next 3-5 days with temps in the 30s and 40s. SAVE YOURSELF THE HEADACHES AND STAY FAR AWAY FROM CARRIER. The quality is subpar for the premium price and I feel this is just going to be the first of many problems with this junk!

Like other reviews we have had many of the same issues. Every change of seasons we have to have service call for a 24vac fuse. We are on our second thermostat, which is not letting us program day temperature. Had circuit boards replaced. This past winter, had the compressor replaced. Were told this will fix the issues we have been having. 3 months later, 24vac fuse call, technician is on our thermostat again. We have the company that installed the unit come in every spring and fall to check the system for proper operation and usually 6 to 8 weeks later it quits working or the 24vac fuse warning comes up. Also have a carrier gas furnace the first year the blower fuse blew. The repair technician left me 2 extra fuses and showed me how to replace it so we did not have to pay someone to come out.

We have a top of the line Carrier Infinity heat pump put in place in 2014. It was installed by an authorized installer who has been installing Carrier systems for 45 years. The unit is supposed to be state of the art and cost over $10K. But in 2015, one year after it was put in place, the system broke down in the summer and a motor had to be replaced. Now in 2016, second year after the installation, the system broke down again and another motor has to be replaced. And it takes more than 10 days to order the motor in todays world when everything you order from Amazon can arrive in 2 days.When I called Carrier to file a complaint, the lady I spoke with was supposed to be a senior level rep, and she was even more disappointing. Please note, I wasnt even asking them for anything. My repairs are covered by a service policy I already had. I just wanted to let them know my frustration as a consumer, and I think given the good reputation I have heard about Carrier, you would think how their customers are feeling about their quality and service. Well, this lady blamed everything on distributors and installers, and said Carrier provides 10 year parts warranty and thats all they can do. She basically said Why are you wasting my time by calling me. without using those words.Well, for a state of the art system such as Carrier Infinity, you probably wouldnt expect to shut down for 2 weeks every year in the hottest days of the summer. And you would probably expect Carrier to care more about the quality and service experienced by their highest paying customers. I need to replace another old HVAC system soon and I never thought I would get anything other than Carrier. Now I will look into what other competing products are out there.

2017 AC Bad Condensor Coil after 1.5 years. Model 24abc636a300. $500 to find leak & add 3 pounds of Freon. $1500 to remove outside unit (take back to Carrier) & install new one. Several leaks on Cond. coils at welds & Baffle plate. Also they dont even install low pressure switches to protect the compressor. These are the notes from AC Tech: Found unit to have small leak in condenser coil. Appears to be in between header plate and coil making it difficult to bubble test. However video indicates a leak with electronic leak detector. Customer not interested in replacing coil under warranty at this time. Customer only wanted to charge unit. Leak will only worsen and refrigerant will leak out again and with no high or low pressure switches compressor damage could occur if unit continues to run with no refrigerant. Unit also has 45+5 mfd battery pack weak and customer declined replacing under warranty as well.

We purchased our air conditioner in 2007 and have had problems 4 out of 5 seasons. Living in Michigan, we basically have only run our air conditioner for a little over a year now. The 1st year, a bad sensor had to be replaced; 2nd year ran okay; 3rd year, it ran constantly and hardly cooled down our home. At the beginning of the 4th year, it ran out of freon and was recharged, and last year it ran out of freon again. The installer found a pinhole in the coil and it had to be replaced. Our installer/servicer was very helpful and worked with us to help keep labor costs down but, Carrier should stand behind their product and cover all labor for warranty parts. I shouldnt have to pay labor charges on factory defective parts. Its very frustrating to have purchased a top-of-the-line unit, only to feel like we ended up with a lemon and have little recourse but to accept Carriers less than satisfactory limited warranty. I get the feeling Carrier couldnt care less about the little guy, once a sale is made. At least the car manufacturers cover labor and parts for warranty work. Type Of Product : Central Air Conditioner, Serial Number : **, Model Number : 24APA324A0030010, Installed Date : 05/17/2007.Update 5/3/12: Surprise, surprise, here it is the beginning of the warm weather season and we turned on the AC today and it isnt working. We will have to wait until I can get a servicer out to find out whats wrong now.

I decided on a Carrier split system for heating and cooling in an older ranch with electric baseboard heat only. Best decision ever!! It's efficient and cheaper to operate than the new Ruud gas system in my old condo. The heat is so warm. It's not anything like the old heat pumps that seemed to throw cool air for heat. My old condo and my house are about the same size. Both are on slabs. My heating/cooling bills at the house are half of the condo's. What a blessing. Thank you Carrier!!

Despite the inverter unit being sold to me as a cost saver, this is clearly not the case. The circuit boards are poor quality and do not last 5 years. Replacement boards cost the price of a new regular air conditioner. No-one advises you that you need to perform rust prevention, this prevention, that prevention when you have it installed, but when it goes wrong they are sure to let you know. I will never again waste my hard earned money on a Carrier aircon, nor an inverter unit. A regular, modern unit consumes roughly the same power as an average fridge/freezer. The cost to maintain an inverter unit is ridiculous.

I have had a Carrier Infinity system for 10 years. Within 3 years the compressor went out. A few years later we had a freeze and the heat pump turned on the outside unit breaking the fan. Carrier refused to cover. A year ago the compressor went out again. Carrier was willing to cover the compressor under a 10 year warranty, but not labor. My contract stated parts and labor. They later, after much negotiation, agreed to replace the condenser (including compressor) for $2500 and would extend a new warranty for 10 years parts and labor. Now the unit dies and its a circuit board. After replacing the unit would not come on again. It took 7 hours on the phone between the tech and Carrier to get it running again. Carrier support was reading a manual to help the tech figure out the problem. Their service even to a technician is a joke. I will never own another Carrier.

Im a homeowner and had two units installed in the two story house I completed in 2012. Its been 1 year and 3 months and Ive had 3 a/c outages. My upstairs unit (3-ton) has been out twice, most recently when the compressor blower motor stopped working. My latest problem is with the downstairs unit (2.5-ton) which needs a new evaporator unit. There is a leak in the copper coil which Im told is common. Most startling to me, however, was how corroded the entire evaporator unit appeared. I took a photo and posted here. The prevailing story I hear from the repair folks is that Carriers technology got way ahead of quality... in an effort to meet the rising efficiency requirements. The parts warranty is helpful, but the labor combined for all three repairs is now at $2000. Oh yeah, and I called Carrier (as a homeowner) to express my dissatisfaction. They towed the line on warranty terms and conditions and wouldnt transfer me to a Manager. Given my experience, I will never purchase Carrier equipment again.

Carrier bought in 2006 has had over 18 service calls on heat pump. Never once fixed more than 3-4 months. Now has a coil leak in heat pump. $6640.00 quoted for new unit. $3700.00 quoted to replace coil. Never buy Carrier again. Carrier customer service could not care less. Out of warranty.

The centrifugal start switch on my blower motor keeps hanging up. When it does, the motor wont start and the main breaker blows. I have fixed this several times by putting the armature in my lathe and turning down the section in the fins that are rubbing on the switch. Attempted to get the OEM motor part number from Carrier but they refuse to give it to me. They say I have to pay a licensed HVAC dealer to get the part number. The last time I tried to get the HVAC dealer to replace my condenser fan motor, the dealer had no idea what motor I had and I had to remove the motor myself and give him the part number on the motor. Carrier has to be the most unhelpful manufacturer I have ever dealt with.

I built my home and had a Carrier heating and air system installed less than 5 years ago. I believed Carrier to be one of the best so it was worth the extra money. I was wrong. In the last 4 and a half years, I have had 9, yes 9, service calls on my system. I have had fans out of balance (one was so bad it would rattle the dishes on the countertop in the kitchen). The main units compressor locked up and had to be replaced. The main thermostat went out and had to be replaced. Theres a freon leak in the upstairs unit and freon has had to be added to both units 4 times. It leaked water condensation in the attic, and now I go to turn it on over the weekend and the downstairs unit blows warm air. It wont cool. It has cost me over $1,300 out of pocket for the things not covered under warranty. Some labor was not covered, some service calls were not covered and, who knew Id have to pay shipping to get replacement parts shipped to me and then pay shipping to have the faulty parts shipped back to Carrier??? What a ** way to do business. The installer, Love Heating and Air in Monroe, NC is worthless and horrible to deal with and now Im getting the runaround with Carrier Corp. Im done with Carrier and wish they would come and rip this crap out of my home. Ill buy the Trane instead or a box fan. At least, the box fan would work.

I bought (3) 2 ton heat pumps for my home, the Carrier Infinity Systems. Compressors have had to be replaced, thermostats have to be replaced, units are just horrible, noisy. I have nothing good to say, I thought I was buying a Rolls Royce got a rambler.

I purchased the Infinity 17 Unit in 2009 with, according to my contract with the dealer, has a 10 year warranty. Recently the compressor went out and upon trying to replace it, I was told the warranty was only good if the products were registered. They (Customer Relations at Corporate Office) stated that registration for the unit was not completed. It only shows the registration for the furnace which extends that warranty from 5 years to 10 but did not show the same for the compressor.Therefore they would not honor the warranty for the compressor. I told them there must be a mistake since why would only one part of the system be registered and not the complete unit. They refused to do anything to remedy the matter. So I am stuck with a bill of several thousand dollars to repair or replace the system. Also, I had to replace the coils three years ago. I purchased this higher priced unit because it is one of their top products and the warranty. I am very disappointed with the unit and with the company response.

Carrier Bryant Furnace - I had a new Carrier Bryant furnace installed in September 2014. Hardly used it for two months and then in November 2014 the thing does not work, and the plumber says he cant repair it. Now I have to try and my $3000 back somehow. Do not use Carrier products.

In 2007, I bought top of line Carrier air conditioner. Yesterday, I had the semi-annual service done only to find out that the coil is leaking and needs to be replaced. The technician said that these coils are defected and Carrier has redesigned them. Even though they are defected, Carrier will only pay for the part and I have to eat over $500 in labor to install it. This doesnt seem right that I have to pay for Carriers mistake. All I know is that I am done with Carrier products.

We installed a new expensive Carrier heat pump/AC system in 2002. Over 14 years we had to replace the Bristol compressor 10 times. Our HVAC service company and Carrier said we were the only ones who had this problem and they did not know why. All lies as I now know. The compressor failed again this year (2016) and the HVAC service company we use said they cant replace the Bristol compressor this time due to a lawsuit between Carrier and Bristol, so we had to replace our whole system. We would never install Carrier again. Carrier charges huge but gives you junk. If we hadnt taken out a $900 10-year labor charge warranty when we bought the system, we would have been out thousands of dollars to replace 10 compressors. Dont ever buy Carrier! They are no longer using Bristol compressors, but the substitute compressor brand they are now using is reputed to be just as bad.

I have a 2005 Carrier Puron system and started having problems in 2011 which was 1 year after the warranty expired on the coils. I had to replace the coil for $1,100 which had a leak. I was told, like many others in this forum, that this is a known defect with Carrier products. I called Carrier and again, as many others have relayed, they did not care. They have a 5 year warranty. I now have the plated 10 year coil. I agree with all the other posts that Carrier is a rip-off and they have no concern for consumers and do not stand behind their products. I would never buy or recommend a Carrier to anyone. My a/c repairman told me Amana has a lifetime warranty and there are better brands that have better warranties.

We purchased ours give or take 8 years ago. It was best deal in our price range and for size wise in comparison to the square footage of our home. I would definitely recommend them to anyone looking to purchase or replace their existing one.

The worst product ever used. Something on the furnace broke and it shredded items in house, endangering human life. The absolute worst furnace ever used. The furnace shredded and burnt stuff in the house. Poor quality product. It happened about 3 years of using it, and then something on the furnace broke, leaking water everywhere. This is a Carrier furnace that uses a boiler. After fixing the water leakage. It started to shred items in the house, causing excruciating pains and sufferings. Please everyone with similar problems with Carrier furnace, should start a class action lawsuit.

Carrier offers boilers with efficiency ranges from 80% AFUE to 90% AFUE*. Carrier is a popular name known for air conditioners, heat pumps, and gas furnaces but Carrier offers other types of HVAC products including Carrier hot water boilers in indoor air quality products that compliment Carriers other HVAC products.

On Dec 29, 2021, I had a Carrier Comfort 2.5 ton 14 Seers heatpump and air handler split system installed. It replaced a very efficient old Trane split system that was just too old and had broken down. The new Carrier heatpump has been nothing but a problem. On heat mode and auto fan it blows cold and ambient air through the registers and is constantly running. It kicks in auxiliary heat in the air handler often cause the heatpump is unable to provide enough hot air by itself to even warm the house and I live in Florida!. I expect my electric bill to go up by $300.00 more a month with this American engineered and built crap. The ac company and installers said this is normal for a Carrier comfort heatpump constantly blowing ambient air in heat mode and constantly running and hardly ever shutting off.Tried calling Carrier to tell them the problem and they referred me back to the ac company. My foreign made Trane heatpump heated the house well before it broke down after 20 years of use. Heard that an American company bought Trane and the new Trane heatpumps being built are also crap. So, that is why I went with Carrier. Next time, I will buy a Bosch heatpump cause American products are poorly engineered and manufactured with planned absolescence, inefficient, not dependable or reliable.... CARRIER comfort American piece of crap.

After a routine check of our vacation home HVAC systems, we were told we should consider replacing the aged units, although they still worked. We decided to spend the $17,000 for two units and set up an install time when we would be there. Install: Day 1 (a Friday): Were told we couldnt use our Nest thermostats. Installers opened crates to find one of the outdoor units had a large dent, but told us the panel would be ordered, and that no internal damage was done.Installers were there until 10:30pm, and said that it wasnt working correctly. They said they would come back Monday.Install: Day 4 (Monday): Installer tried again but couldnt get things going. Said he spent 2 hours on phone with Carrier support. He said part needed and hed return next day. That night we found water dripping in our closet due to drain pan under attic air handler overflowing. Drain pipe not working and float cutoff switch not working. Called night number and were told it would be 10pm, so we said come first thing in the morning Tuesday. Install: Day 5 (Tuesday) Installer came at 3pm. Said part not arrived yet, but got drain pan working. Install: Day 6 (Wednesday) Got call from dealer service department wanting to know what day the next week they could install part. I said that was unacceptable because we would not be here. After 2 calls they agree to send someone next day first thing. Install: Day 7 (Thursday) Installer came at 10am, and after what he said were hours on the phone with Carrier support they were going to install new units. The only ones available were smaller but would be fine. (Im wondering why they recommended the larger, more expensive ones in the first place.)Install: Day 8 (Friday) Installer arrives at 1pm with new units. As I write this they are installing the new units, so I decided to download the Infinity app and get ready for remote access that weve enjoyed for years with Nest. I got the app downloaded and started to register. My screen (mobile and computer) says Carrier server is down, try later. I called support and they said server has been down 11 days, and they do not have an estimated time for it to be operational. Support is open Monday-Friday, so I asked them if I must be at the thermostat to connect it to my phone. They confirm that, so because I must leave Sunday to go home I will not be able to setup remote access. I will not be able to remotely see what the temp is so I wont know if the units are working.If they dont at least get the units working correctly today I plan to have them removed and replaced with Trane units. Please notice that I have attempted to be factual and not be emotional or let my anger, frustration, and home temperature (its over 90 degrees again today) show through. I only write this to let prospective buyers know to think twice before selecting Carrier.

My Carrier Infinity Air Conditioner unit cost roughly $9,500 to install and was put in four years ago. My A/C stopped working because the condensing coil was leaking from the riser. This caused it to run under charged and blew the compressor. Now I need a new compressor, a new coil, a new capacitor, a new wire harness for the compressor and a new filter dryer - essentially building a new A/C unit. Carrier will cover the parts but the labor will cost $1,455 and they will not cover that cost. IF the tech agrees its a quality control issue they will see what they can do. Obviously by the number of complaints about Carriers coils, this IS a quality issue.

Got Carrier Infinity Greenspeed in November 2012. Got the 97.2% efficiency infinity modulating natural gas furnace and 4 ton 17 SEER air conditioning unit. I do love the low speed variable heating as it keeps a gentle constant heat. Cooling is also good and efficient. Both units, however, have been unreliable. In October 2014 the furnace broke. We needed a new inducer motor. They dont keep parts at Carrier, so it took several days to get the part. Cost me $400 for labor and other parts. In July 2015 air conditioning unit leaked and had to have coolant replaced. In May 2016, the unit would not start during routine twice a year maintenance service agreement we had with installer. There were multiple leaks and the entire outside unit and coil had to be replaced. The installer was great and didnt charge for labor since we had repeated problems with the unit. Carrier again did not have parts on hand, so had to wait a week on parts. Still cost me $600 in additional installer parts not covered by Carrier. So, on this supposed high end system, both the furnace and air conditioner have had major failures in under 3 years of use and these have cost me over $1000 out of pocket. Obviously, my conclusion is that Carrier Infinity Greenspeed is a piece of junk.

Carrier Comfort 80 gas furnace blower motor & cage failure- The blower motor and blower squirrel cage have both recently failed on this 9-year-old unit. Preventive maintenance twice yearly has been consistently scheduled. Warranty was for 5 years for all parts except heat exchanger (10 years). Cost to replace both of these items was $960 less my 15% discount for being a preferred customer. VERY HIGH PRICES! The tech volunteered that Carriers prices on replacement parts is high. I found the same parts on other HVAC supplier websites for much less - I was initially not comfortable with handling the parts change out, but now seeing how it was done, could probably have done it myself & saved a bunch of $. I contacted Carrier, but got no response from them. Had asked for some $ warranty assistance since these parts failed prior to 10 years of service - my tech said that after 2010, Carrier increased their warranty to 10 years on other parts. This is the first time I have had any blower failures on a furnace earlier than 20 years of service. Apparently they just dont make em like they used to and Carrier doesnt really care about their residential consumer customers either. I wont be replacing any of this equipment (when the time comes) with Carrier!

When I bought Carrier I bought 3 tons heat pumps. Carrier decided to change their world class heat pump for a “shell” pump on my models, which I had 12 visits in two years, they covered in warranty one heat pump, and installed the original old style. Now I have 2 pumps not work, and 3 ($1000) thermostats out-of-warranty. This purchase was horrible, all the carrier dealers stat oh... you bought that year... youre screwed.

Well its that time of year again when the old AC unit that is only 5 years old fails. You would think spending 6K on a new name brand ac unit would last a few years at least. Once installed the unit lasted about 13 months and the coil leaked inside the house. A new one was installed and Puron re-added and all good, maybe a one off defect right? 4 years later same thing, now the HVAC guys all say its the fact they used copper and aluminum coils with high pressure Puron, a known failure waiting to happen. The new coil I have coming this week is all aluminum, and it covered under warranty still! But not the 2K plus cost for dyte, Puron, then replacement and yes more Puron! Calling Carrier is a joke, you get top level support that says I need to send an email to the review board. Buy some cheap Chinese AC unit. It will last longer or at least as long.

Carrier Infinity heat pump residential - Similar problems as most others have listed. I purchased a top of the line Infinity System 3 1/2 years ago. The unit never cooled properly. Total Air Care was ignorant about the Puron system; they didnt know why it wasnt cooling. Ive had the TXV replaced twice. Ive had a motor capacitor replaced. Ive had the compressor relocated closer to the air handler. The last Carrier tech said I needed the evaporator coils replaced, $400 for labor. I installed a powered attic fan and had the attic re-insulated. Ive spent close to $2,500.00 on getting it to work properly. I still come home to a warm home. Ill never buy another Carrier - sounds like a little class action may be needed.

After coming home from work on a hot, sunny, Friday afternoon, I noticed the inside of the house was MUCH hotter than what the thermostat was set for. After going outside and checking the heat pump, I noticed that the copper lines were frozen and the fan wasnt spinning. After calling the installation company, they said they wouldnt be able to be out there until Saturday afternoon (of course!). The repair technician came out Saturday around 3:00 pm and said that it was the motor and that Carrier knows these are bad motors, but they wont do anything about them until they break. They last roughly 2-2.5 years before they need replaced. I have already replaced at least 40 this year and thats just me.... I have three other partners!. Of course, he said that it wouldnt be able to be taken care of until Monday after he contacted Carrier. On Monday, he ordered the part and Tuesday around noon, he actually came and fixed it. If anyone knows what the weather is like in September in South Carolina, then you know that there were FOUR VERY UNCOMFORTABLE NIGHTS OF SLEEP (youre not getting much sleep when it is hot and humid... all a fan did was circulate the hot air). I wish that I had known about all these problems with Carrier before we built our house 2.5 years ago! I can assure you that from here on out, that for me, it will be hard to stop a Trane. I have asked two different technicians now, who they thought makes the best unit, and both unquestionably said Trane. Thanks to Carrier, I am now out $300 because of a known faulty motor (sorry to everyone else who has spent more money because I know that sounds like chump change, but I definitely would like spending that on something else). If any car manufacturer had known issues, they would put out a recall and fix the unit.... Why isnt Carrier doing the same? Unscrupulous is word that comes to mind...

Had a new Carrier furnace and A/C installed in August 2013. It totally worked fine until last summer. After several visits by several technicians they replaced a low pressure switch and a coil in the inside unit. Last occurred last fall. I turn the unit on the spring and no A/C. Called the company that installed it since it is still under the 5 year labor 10 year parts warranty. It required 2 lbs of Puron. They never checked for a leak but recommended I have a nitrogen test that would cost me $800.00. I asked why I have to pay for a leak test under warranty. The tech told me that it is not covered under warranty. So they will continue to put Freon in until it goes out of warranty in August then it is all on me. A wasted 9k. Never ever buy or recommend Carrier products to anyone.

Two-year-old system does not remove humidity from our home despite four service calls and a compressor replacement. The condensing unit never drains water and the Carrier dealer who installed the unit says all is okay/normal. As a result the humidity level in the house is always high, sometimes more than it is inside. Only two adults live in the home and the bathrooms/laundry room are well vented/exhausted. Does not appear from what I read that Carrier cares. Can the problem be linked to the refrigerant no longer being Freon? I have placed a portable dehumidifer upstairs which helps some and removes several quarts of water daily. We live in high humidity Indiana. Suggestions?

We purchased a carrier system in Nov. 2019, it had a condenser leak in Dec.2020, four days later the compressor stopped working. Total labor for both jobs was $2500.00 dollars. Carrier’s customer service denied payment for all or part of the labor. The exact statement in the e-Mail from Mr. Lee ** was “Carrier only pays for excessive or expensive labor cost”. David L Gitlin Dave President/CEO, Carrier Global Corp stated in on the company’s website “we want to do what is right”.

My June 2005 Carrier heat pump (50XZ036, packaged unit, 36KBTU or 3 tons) failed within the 1st year while parts and labor warranty was in effect. The evaporator/inside coil had to be replaced after more than one attempt by the original Carrier installer to simply recharge the leaked Puron (a trademark for R0410A, a type of Freon as for the old R22), and I hope for the best. The unit would quit cooling after several weeks of use. I heard on this site that 2005/6 evaporator failures are from using R22 evaporator coils, which are not designed to withstand Puron operating pressures.In 2009, when the parts-only warranty was in effect, the 2006 replaced evaporator coil failed, and I paid a second Carrier installer $450+ to replace the evaporator coil. The original installer wanted $900 in labor, of which Puron was ~$400. The 2nd installer had a lower Puron markup of x4 (~$25/#) versus x9 (~$50/#) for the 1st installer. Puron sells for $155 for 25 lbs. The 2nd installer in 2012 charges $35/# for Puron, R-414a.In 2010, the compressor failed to run for 20 hours; only the inside fan would run, and the failure corrected itself before the 2nd installer came to investigate the failure. The heat pump worked well in the next two years.In June 2012, I came back from vacation to a warm house (81F). The compressor was running all the time, and 72F air was coming out of the vent instead of ~58F. The evaporator coil leaked Puron, and it ices over. After 3 failed evaporator coils from the same cause of external tubing corrosion caused by the design of cooper tubing contacting aluminum fins, I can say that these non-moving and non-electronic components are a manufacturing defect.I am seeking that Carrier Corp. turn back the clock to 2006 and repair my evaporator coil for free for both parts and labor with the improved evaporator coil - something they should have done in the first repair in 2006. There is a Carrier October 2005 literature citing the option of getting a corrosion-resistant evaporator coil. This was never told to me in 2006 or in 2009. Why is there an option to a consumer to buy the $5000 heat pump with the poorly designed evaporator coil or the one with the improved tin version of evaporator coil? No one would buy the inferior product.The northern Alabama distributor mentioned that since 2010, Carrier will not install the inferior evaporator coils in the SE US. Just yesterday, this same distributor preferred to sell my 2nd installer the inferior evaporator coil while he had the improved tin evaporator coil. I asked him what his markup was in trying to sell these inferior evaporator coils. Oh, that is proprietary. After talking with the 2nd installer of my findings of the improved tin coil and the 2010 Carrier SE US directive, he called the distributor and found that the tin evaporator coil is available and cost less that the inferior one. If I do not get satisfaction from Carrier Corp., I am taking everybody to Small Claims Court.

I built a new home within early 2012 in South Carolina and installed three 2 ton Carrier heat pump systems and one 3 ton system. (4 systems in all) In 2015 the first copper coil developed a leak due to formicary corrosion (supposedly a reaction with my foam insulation) and the other 3 all followed by mid 2017 and were replaced by aluminum coils. (Warranty) Supposedly the aluminum would not react with the foam insulation. However, an aluminum coil installed in 2016 has now failed/leaked due to the same issue. The aluminum coils are only warranted for one year so now I am faced with replacing the whole air handler in order to get a 10 year warranty since replacing the coil costs almost the same amount with only a one year warranty. I understand the same issue is rampant in the industry so I do not understand how any company can survive by providing a product they know is destined for early failure. I have heard that tin plating solves the issue but I also heard that aluminum solved the issue. Obviously, I am disgusted with Carrier but do not know how to force them to upfront with the issue and take care of their customers.